郑昱, 贺昌岩, 林闯, 韩少峰, 广晨汉, 陈子路, 杨洋. 眼科手术器械操作黏弹性组织的导纳控制方法[J]. 机器人, 2021, 43(3): 289-295. DOI: 10.13973/j.cnki.robot.200497
引用本文: 郑昱, 贺昌岩, 林闯, 韩少峰, 广晨汉, 陈子路, 杨洋. 眼科手术器械操作黏弹性组织的导纳控制方法[J]. 机器人, 2021, 43(3): 289-295. DOI: 10.13973/j.cnki.robot.200497
ZHENG Yu, HE Changyan, LIN Chuang, HAN Shaofeng, GUANG Chenhan, CHEN Zilu, YANG Yang. An Admittance Control Method for Ophthalmic Surgery Instrument Manipulating Viscoelastic Tissue[J]. ROBOT, 2021, 43(3): 289-295. DOI: 10.13973/j.cnki.robot.200497
Citation: ZHENG Yu, HE Changyan, LIN Chuang, HAN Shaofeng, GUANG Chenhan, CHEN Zilu, YANG Yang. An Admittance Control Method for Ophthalmic Surgery Instrument Manipulating Viscoelastic Tissue[J]. ROBOT, 2021, 43(3): 289-295. DOI: 10.13973/j.cnki.robot.200497

眼科手术器械操作黏弹性组织的导纳控制方法

An Admittance Control Method for Ophthalmic Surgery Instrument Manipulating Viscoelastic Tissue

  • 摘要: 基于广义Maxwell黏弹性模型建立手术器械与眼组织之间的黏弹性接触模型,并通过力松弛实验对接触模型的参数进行辨识.进而在此基础上提出一种导纳控制方法,通过控制手术器械的位移实现对接触力的控制.该方法将传统的导纳控制器替换为比例-积分(PI)控制器,从而将黏弹性接触模型中的理想微分环节替换为1阶微分环节.替换后,在低频段,尤其是频率趋近于0时的幅频响应可得到提升并保持稳定,从而避免幅频响应过低导致的接触力衰减.通过对离体猪眼球进行力控制实验验证了该控制方法的有效性.实验结果表明,阶跃力平均误差约为4.6%,响应时间约为2.5 s,无明显超调,并可实现一定频率的正弦力输出.阶跃力输出精度可以满足机器人辅助眼科手术的要求.

     

    Abstract: A viscoelastic contact model between surgical instruments and ocular tissue is established on the basis of generalized Maxwell viscoelastic model, and the contact model parameters are identified through force relaxation experiment. On top of that, an admittance control method is developed. The contact force is controlled through adjusting the displacement of surgical instruments. In the proposed method, the traditional admittance controller is taken place by the proportionalintegral (PI) controller. In this way, the ideal differential element in viscoelastic contact model is replaced by the 1st order differential element. After replacement, the amplitude-frequency response at low frequency can be improved and kept stable, especially when the frequency approaches zero. The attenuation of contact force caused by low amplitude-frequency response can be avoided. Some force control experiments on in vitro pig eyes are carried out to prove the effectiveness of the proposed method. The experiment results show that the average error and response time of step force are 4.6% and 2.5 s respectively, no obvious overshot occurs, and the sinusoidal force with certain frequency can be output. The output accuracy of step force meets the requirements of robot-assisted ophthalmic surgery.

     

/

返回文章
返回